TM 55-2815-574-24
0083
REMOVAL
1.
Place a drain pan under fuel filter adapter (Figure 1, Item 8).
WARNING
Accidental or intentional introduction of liquid contaminants into the environment
may result in a violation of state, federal, and military regulations. Refer to local
environmental office for information concerning storage, use, and disposal of
these liquids. Failure to comply may cause damage to environment and health
of personnel. Seek medical attention in the event of injury.
Fuel/solvent/oil is slippery and may cause falls. Wipe up spillage immediately with
rags. Dispose of materials in accordance with local hazardous waste disposal
procedures. Failure to comply may result in personnel injury or death.
Oils and fluids are flammable and may cause irritation to the eyes or skin. Use in
well-ventilated areas and keep away from heat and open flame. Wear protective
goggles and clothing. In case oil or fluid comes in contact with:
Eyes, flush immediately with water.
Skin, wash with soap and water.
Failure to comply may result in personnel injury or death.
Fuel is very flammable and can explode easily.
When working with fuel, post signs that read: ʺSMOKING IS PROHIBITED
ABOARD THIS VESSEL".
Personnel must wear chemical resistant gloves when handling fuels.
Promptly wash exposed skin and change fuel-soaked clothing.
In case of engine room fire, evacuate the engine room immediately. Do not
re-enter the engine room until the engine room has been ventilated and the air
quality has been tested.
Keep fuel away from open flame or extreme heat.
Always keep fire extinguisher within easy reach when working with fuel. Failure to
comply may result in personnel injury or death.
2.
Disconnect fuel line (Figure 1, Item 3) from elbow (Figure 1, Item 1).
3.
Remove elbow (Figure 1, Item 1) from fuel filter adapter (Figure 1, Item 8).
4.
Disconnect fuel line (Figure 1, Item 4) from elbow (Figure 1, Item 5).
5.
Remove elbow (Figure 1, Item 5) from fuel filter adapter (Figure 1, Item 8).
6.
Disconnect fuel line (Figure 1, Item 2) from elbow (Figure 1, Item 6).
7.
Remove elbow (Figure 1, Item 6) from fuel filter adapter (Figure 1, Item 8).
8.
Remove pipe plug (Figure 1, Item 7) from fuel filter adapter (Figure 1, Item 8).
0083-2
